The ACh-30 was a development of the experimental AN-1RTK turbo-supercharged diesel engine that had begun development in the early 1930s. It was initially designated as the AD-5 when development began in the
sharashka attached to Factory () No. 82 at
Tushino Airport in 1939. Construction of the first five prototypes began at the end of that year and it passed its tests in early 1940. Preparations to begin series manufacture at Factory No. 82 began in May 1940, but actual production was delayed until 1941 when forty-four were built as the M-30. Production was planned to be transferred to the
Kharkov Tractor Factory, but this was cancelled before any engines were built. The M-30 had proven to be unsatisfactory in service, as it was unreliable and troublesome at high altitudes and in cold conditions. Specific problems were its failure to deliver full rpm and it suffered from oil blowouts and failures of the oil pumps. Production was cancelled when Factory No. 82 was forced to evacuate in the fall of 1941 because of the German advance on Moscow. Production was reinitiated in the evacuated workshops of Factory No. 82 by Factory No. 500 in June 1942, thirty-two engines being completed during the year. Development of supercharged versions began about the same time, using geared,
centrifugal-type superchargers adapted from the
Mikulin AM-38 and the
Klimov M-105 engines with
intercoolers. That from the AM-38 was more successful and was put into production as the M-30B. Thirty-five incomplete M-30 engines were modified beginning in August into M-30Bs and then thirty-four M-30Bs were produced during the rest of 1942. Oddly the ACh-30B, as the engine was now known, was not formally accepted for series production until 19 June 1943, although production had begun quite a bit earlier than that. Factory No. 45 began production in the fourth quarter of 1943. Some 1450 ACh-30Bs were built before production ended at both factories in September 1945. The ACh-30B was tested as a
motorjet in which the jet engine's
compressor was driven by an incorporated piston engine (as opposed to being driven by a
turbine extracting power from the jet's exhaust as in a normal
turbojet). Versions of the ACh-30 were evaluated on the
Ilyushin Il-6 and the ANT-67, a long-range version of the
Tupolev Tu-2, but neither aircraft was put into production. It was also proposed for use on the
Tupolev Tu-8S and the MN executive transport, but neither of those projects progressed past design proposal stage. ==Variants==