Falcon Heavy

Concepts for a Falcon Heavy launch vehicle using three Falcon 1 core boosters, with an approximate payload-to-LEO capacity of two tons, were initially discussed as early as 2003. The concept for three core booster stages of the company's then as-yet-unflown Falcon 9 was referred to in 2005 as the Falcon 9 Heavy. SpaceX unveiled the plan for the Falcon Heavy to the public at a Washington, D.C., news conference in April 2011, with an initial test flight expected in 2013. A number of factors delayed the planned maiden flight to 2018, including two anomalies with Falcon 9 launch vehicles, which required all engineering resources to be dedicated to failure analysis, halting flight operations for many months. The integration and structural challenges of combining three Falcon 9 cores were more difficult than expected. In July 2017, Elon Musk said, "It actually ended up being way harder to do Falcon Heavy than we thought. ... We were pretty naive about that". The initial test flight for the first Falcon Heavy lifted off on February 6, 2018, at 20:45 UTC, carrying its dummy payload, Elon Musk's personal Tesla Roadster, beyond Mars orbit. Conception and funding Musk first mentioned Falcon Heavy in a September 2005 news update, referring to a customer request from 18 months prior. Various solutions using the planned Falcon 5 (which was never flown) had been explored, but the only cost-effective, reliable iteration was one that used a 9-engine first stage—the Falcon 9. The Falcon Heavy was developed using private capital with Musk stating that the cost was more than US$500 million. No government financing was provided for its development. Design and development , three versions of Falcon 9 v1.1, three versions of Falcon 9 v1.2 (Full Thrust), three versions of Falcon 9 Block 5, Falcon Heavy and Falcon Heavy Block 5 The Falcon Heavy design is based on Falcon 9's fuselage and engines. By 2008, SpaceX had been aiming for the first launch of Falcon 9 in 2009, while "Falcon 9 Heavy would be in a couple of years". Speaking at the 2008 Mars Society Conference, Musk also indicated that he expected a hydrogen-fueled upper stage would follow two to three years later (which would have been around 2013). By April 2011, the capabilities and performance of the Falcon 9 vehicle were better understood, SpaceX having completed two successful demonstration missions to low Earth orbit (LEO), one of which included reignition of the second-stage engine. At a press conference at the National Press Club in Washington, D.C., on April 5, 2011, Musk stated that Falcon Heavy would "carry more payload to orbit or escape velocity than any vehicle in history, apart from the Saturn V Moon rocket ... and Soviet Energia rocket". In 2015, SpaceX announced a number of changes to the Falcon Heavy rocket, worked in parallel to the upgrade of the Falcon 9 v1.1 launch vehicle. In December 2016, SpaceX released a photo showing the Falcon Heavy interstage at the company headquarters in Hawthorne, California. Testing By May 2013, a new, partly underground test stand was being built at the SpaceX Rocket Development and Test Facility in McGregor, Texas, specifically to test the triple cores and twenty-seven rocket engines of the Falcon Heavy. By May 2017, SpaceX conducted the first static fire test of flight-design Falcon Heavy center core at the McGregor facility. In July 2017, Musk discussed publicly the challenges of testing a complex launch vehicle like the three-core Falcon Heavy, indicating that a large extent of the new design "is really impossible to test on the ground" and could not be effectively tested independent of actual flight tests. The first Falcon Heavy static fire test was conducted on January 24, 2018. SpaceX refurbished Launch Complex 4E at Vandenberg AFB to accommodate Falcon 9 and Heavy. The first launch from the Cape Canaveral, Florida east coast launch complex was planned for late 2013 or 2014. Due partly to the failure of SpaceX CRS-7 in June 2015, SpaceX rescheduled the maiden Falcon Heavy flight in September 2015 to occur no earlier than April 2016. The flight was to be launched from the refurbished Kennedy Space Center Launch Complex 39A. The flight was postponed again to late 2016, early 2017, summer 2017, late 2017 and finally to February 2018. At a July 2017 meeting of the International Space Station Research and Development meeting in Washington, D.C., Musk downplayed expectations for the success of the maiden flight: There's a real good chance the vehicle won't make it to orbit ... I hope it makes it far enough away from the pad that it does not cause pad damage. I would consider even that a win, to be honest. He released pictures in the following days. However, due to the U.S. government partial shutdown that began on January 20, 2018, the testing and launch were further delayed. The static fire test was conducted on January 24, 2018. Musk confirmed via Twitter that the test "was good" and later announced the rocket would be launched on February 6, 2018. On February 6, 2018, after a delay of over two hours due to high winds, Falcon Heavy lifted off at 20:45 UTC. However, only one of the three engines on the center booster that were intended to restart ignited during descent, causing the booster to be destroyed upon impacting the ocean at a speed of over . Initially, Elon Musk tweeted that the Roadster had overshot its planned heliocentric orbit, and would reach the asteroid belt. Later, observations by telescopes showed that the Roadster would only slightly exceed the orbit of Mars at aphelion. Later flights specifications on the launch pad in June 2019 A year after the successful demo flight, SpaceX had signed five commercial contracts worth US$500–750 million, meaning that it had managed to cover the development cost of the rocket. The second flight, and first commercial one, occurred on April 11, 2019, launching Arabsat-6A, with all three boosters landing successfully for the first time. The third flight occurred on June 25, 2019, launching the STP-2 (U.S. Department of Defense Space Test Program) payload. and the second of which being USSF-67, which was launched 11 weeks after USSF-44. ViaSat selected the Falcon Heavy in late 2018 for the launch of its ViaSat-3 satellite which was scheduled to launch in the 2020–2022 timeframe; however it would not launch until May 1, 2023. On October 13, 2023, Falcon Heavy embarked on its 8th flight carrying NASA's Psyche probe to the asteroid 16 Psyche. This mission only had the side boosters return to Earth with the center core expended, a decision made to create more tolerable margins for the mission. Following the announcement of NASA's Artemis program of returning humans to the Moon, the Falcon Heavy rocket has been mentioned several times as an alternative to the expensive Space Launch System (SLS) program, but NASA decided to exclusively use SLS to launch the Orion capsule. Falcon Heavy was contracted to transport the Dragon XL spacecraft to the Lunar Gateway. It was also selected to launch the first two elements of the Lunar Gateway, the Power and Propulsion Element (PPE), and the Habitation and Logistics Outpost (HALO). However, in March 2026, NASA announced it would pause development of Gateway and reallocate hardware toward a lunar surface base. Falcon Heavy will launch Astrobotic Technology's Griffin lander as part of the Artemis Program's Commercial Lunar Payload Services (CLPS) initiative. On October 14, 2024, Falcon Heavy transported NASA's Europa Clipper into space to explore Jupiter's moon Europa. == Design ==

Falcon Heavy consists of a structurally strengthened Falcon 9 as the "core" component, with two additional Falcon 9 first stages with aerodynamic nose-cones mounted outboard serving as strap-on boosters, conceptually similar to the Delta IV Heavy launcher and proposals for the Atlas V Heavy and Russian Angara A5V. This triple first stage carries a standard Falcon 9 second stage, which in turn carries the payload in a fairing. Falcon Heavy has the second highest lift capability of any operational rocket, with a payload of to low Earth orbit, to Geostationary Transfer Orbit, and to trans-Mars injection. The rocket was designed to meet or exceed all current requirements of human rating. The structural safety margins are 40% above flight loads, higher than the 25% margins of other rockets. Falcon Heavy was designed from the outset to carry humans into space and it would restore the possibility of flying crewed missions to the Moon or Mars. and each core includes four extensible landing legs. To control the descent of the boosters and center core through the atmosphere, SpaceX uses four retractable grid fins at the top of each of the three Falcon 9 boosters, which extend after separation. Immediately after the side boosters separate, three engines in each continue to burn for a few seconds in order to control the booster's trajectory safely away from the rocket. The grid fins then deploy as the boosters turn back to Earth, followed by the extending of the landing legs. The side boosters land softly on the ground in fully/partially reusable launch configuration. The center core continues to fire until stage separation. In fully reusable launches, its grid fins and legs deploy and the center core touches down on a drone ship. If boosters are to be expended, then the landing legs and grid fins are omitted from the vehicle. The landing legs are made of carbon fiber with an aluminum honeycomb structure. The four legs stow along the sides of each core during liftoff and extend outward and down just before landing. Most Falcon Heavy launches have used a second stage equipped with a medium or long mission‑extension kit, which enable a longer coast phase between second‑stage ignitions. The kit includes strengthened COPV tanks for pressurization control, additional TEA-TEB ignition fluid, and most visibly, a gray band painted on the metal skin over the RP-1 tank, which absorbs sunlight and helps prevent the propellant from freezing during the long coast phase. == Rocket specifications ==

The Falcon Heavy uses a interstage attached to the first stage core. The overall length of the vehicle at launch is , and the total fueled mass is . Without recovery of any stage, the Falcon Heavy can theoretically inject a payload into a low Earth orbit, or to Venus or Mars. The Falcon Heavy includes first-stage recovery systems, to allow SpaceX to return the first stage boosters to the launch site as well as recover the first stage core following landing at an Autonomous Spaceport Drone Ship barge after completion of primary mission requirements. These systems include four deployable landing legs, which are locked against each first-stage tank core during ascent and deploy just prior to touchdown. Excess propellant reserved for Falcon Heavy first-stage recovery operations will be diverted for use on the primary mission objective, if required, ensuring sufficient performance margins for successful missions. The nominal payload capacity to a geostationary transfer orbit (GTO) is with recovery of all three first-stage cores (the price per launch is US$97 million), versus in fully expendable mode. The Falcon Heavy can also inject a payload into GTO if only the two side boosters are recovered. == Capabilities ==

in 2019 The partially reusable Falcon Heavy falls into the heavy-lift range of launch systems, capable of lifting into low Earth orbit (LEO), under the classification system used by a NASA human spaceflight review panel. A fully expendable Falcon Heavy is in the super heavy-lift category with a maximum payload of to LEO. The initial concept (Falcon 9-S9 2005) envisioned payloads of to LEO, but by April 2011 this was projected to be up to to translunar trajectory, and on a trans-Martian orbit to Mars. By late 2013, SpaceX raised the projected GTO payload for Falcon Heavy to . In April 2017, the projected LEO payload for Falcon Heavy was raised from . The maximum payload is achieved when the rocket flies a fully expendable launch profile, not recovering any of the three first-stage boosters. Returning all three boosters to the launch site rather than landing them on drone ships would yield about 30 t of payload to LEO. Reusability land in unison at Cape Canaveral Landing Zones 1 and 2 following a test flight on February 6, 2018 From 2013 to 2016, SpaceX conducted parallel development of a reusable rocket architecture for Falcon 9, that applies to parts of Falcon Heavy as well. Early on, SpaceX had expressed hopes that all rocket stages would eventually be reusable. SpaceX has since demonstrated routine land and sea recovery of the Falcon 9 first stage, and has successfully recovered multiple payload fairings. In the case of Falcon Heavy, the two outer cores separate from the rocket earlier in the flight, and are thus moving at a lower velocity than in a Falcon 9 launch profile. but did not execute this plan. Falcon Heavy payload performance to geosynchronous transfer orbit (GTO) is reduced by the reusable technology, but at a much lower price. When recovering all three booster cores, GTO payload is . Propellant crossfeed Falcon Heavy was originally designed with a "propellant crossfeed" capability, whereby the center core engines would be supplied with fuel and oxidizer from the two side cores until their separation. This approach had previously been proposed by Vladimir Chelomei for the UR-700 launch system. Operating all engines at full thrust from launch, with fuel supplied mainly from the side boosters, would deplete the side boosters sooner, allowing their earlier separation to reduce the mass being accelerated. This would leave most of the center core propellant available after booster separation. Musk stated in 2016 that crossfeed would not be implemented. Instead, the center booster throttles down shortly after liftoff to conserve fuel, and resumes full thrust after the side boosters have separated. == Launch prices ==

At an appearance in May 2004 before the United States Senate Committee on Commerce, Science, and Transportation, Musk testified, "Long term plans call for development of a heavy lift product and even a super-heavy, if there is customer demand. We expect that each size increase would result in a meaningful decrease in cost per pound to orbit. ... Ultimately, I believe US$500 per pound or less is very achievable". This goal stated by Musk in 2011 is 35% of the cost of the lowest-cost-per-pound LEO-capable launch system in a 2001 study: the Zenit, a medium-lift launch vehicle that could carry into LEO for US$35–50 million. In 2011, SpaceX stated that the cost of reaching low Earth orbit could be as low as if an annual rate of four launches can be sustained, and as of 2011 planned to eventually launch as many as 10 Falcon Heavies and 10 Falcon 9s annually. US$83–128 million in 2012, US$77–135 million in 2013, US$85 million for up to to GTO in 2014, US$90 million for up to to GTO in 2016. From 2017 to early 2022, the price has been stated at US$150 million for to LEO or to GTO (fully expendable). This equates to a price of US$2,350 per kg to LEO and US$5,620 per kg to GTO. In 2022, the published price for a reusable launch was $97 million. In 2022 NASA contracted with SpaceX to launch the Nancy Grace Roman Space Telescope on a Falcon Heavy for approximately $255 million, including launch service and other mission related costs. The nearest competing U.S. rocket was United Launch Alliance's Delta IV Heavy with a LEO payload capacity of costs US$12,340 per kg to LEO and US$24,630 per kg to GTO. The Delta IV Heavy was retired in 2024. Competitors from 2024 onwards may include Blue Origin's New Glenn (45 t to LEO), Relativity Space's Terran R (34 t to LEO), and United Launch Alliance (ULA) Vulcan Centaur (27 t to LEO). From late 2025 onwards, the SpaceX Starship (100+ t to LEO) may also be included. == Launches and payloads ==

Due to improvements to the performance of Falcon 9, some of the heavier satellites flown to GTO, such as Intelsat 35e and Inmarsat-5 F4, were launched before the debut of Falcon Heavy. SpaceX anticipated the first commercial Falcon Heavy launch would be three to six months after a successful maiden flight, but due to delays, the first commercial payload, Arabsat-6A was successfully launched on April 11, 2019, a year and two months after the first flight. SpaceX hoped to have 10 launches every year from 2021 on, but there were no launches in 2020, 2021 or 2025. Future launches First commercial contracts In May 2012, SpaceX announced that Intelsat had signed the first commercial contract for a Falcon Heavy flight. It was not confirmed at the time when the first Intelsat launch would occur, but the agreement had SpaceX delivering satellites to geosynchronous transfer orbit (GTO). In August 2016, it emerged that this Intelsat contract had been reassigned to a Falcon 9 Full Thrust mission to deliver Intelsat 35e into orbit in the third quarter of 2017. Performance improvements of the Falcon 9 vehicle family since the 2012 announcement, advertising to GTO for its expendable flight profile, enabled the launch of this 6 t satellite without upgrading to a Falcon Heavy variant. In 2014, Inmarsat booked three launches with Falcon Heavy, but due to delays, switched a payload to Ariane 5 for 2017. Similarly to the Intelsat 35e case, another satellite from this contract, Inmarsat 5-F4, was switched to a Falcon 9 Full Thrust due to the increased liftoff capacity. The remaining contract covered the launch of Inmarsat-6 F1 in 2020 on a Falcon 9. Department of Defense contracts In December 2012, SpaceX announced its first Falcon Heavy launch contract with the United States Department of Defense (DoD). The United States Air Force Space and Missile Systems Center awarded SpaceX two Evolved Expendable Launch Vehicle (EELV)-class missions, including the Space Test Program 2 (STP-2) mission for Falcon Heavy, originally scheduled to be launched in March 2017, to be placed at a near circular orbit at an altitude of , with an inclination of 70.0°. In April 2015, SpaceX sent the U.S. Air Force an updated letter of intent outlining a certification process for its Falcon Heavy rocket to launch national security satellites. The process included three successful flights of the Falcon Heavy including two consecutive successful flights, and the letter stated that Falcon Heavy can be ready to fly national security payloads by 2017. But in July 2017, SpaceX announced that the first test flight would take place in December 2017, pushing the second launch (Space Test Program 2) to June 2018. SpaceX was awarded 40% of the launches in Phase 2 of the National Security Space Launch (NSSL) contracts, which includes several launches, a vertical integration facility, and development of a larger fairing, from 2024 to 2027. Space Test Program 2 (STP-2) mission The payload for the STP-2 mission of the Department of Defense included 25 small spacecraft from the U.S. military, NASA, and research institutions: The Green Propellant Infusion Mission (GPIM) was a payload; it is a project partly developed by the U.S. Air Force to demonstrate a less-toxic propellant. Another secondary payload is the miniaturized Deep Space Atomic Clock that is expected to facilitate autonomous navigation. The U.S. Air Force Research Laboratory's Demonstration and Science Experiments (DSX) has a mass of and will measure the effects of very low frequency radio waves on space radiation. but the ballast mass was later omitted from the total mass for the payload stack. NASA contracts Solar System transport missions In 2011, NASA Ames Research Center proposed a Mars mission called Red Dragon that would use a Falcon Heavy as the launch vehicle and trans-Martian injection vehicle, and a variant of the Dragon capsule to enter the Martian atmosphere. The proposed science objectives were to detect biosignatures and to drill approximately underground, in an effort to sample reservoirs of water ice known to exist under the surface. The mission cost was projected to be less than US$425 million, not including the launch cost. SpaceX 2015 estimation was to the surface of Mars, with a soft retropropulsive landing following a limited atmospheric deceleration using a parachute and heat shield. Beyond the Red Dragon concept, SpaceX was seeing potential for Falcon Heavy and Dragon 2 to carry science payloads across much of the Solar System, particularly to Jupiter's moon Europa. Psyche, Europa Clipper, and Dragonfly NASA chose Falcon Heavy as the launch vehicle for its Psyche mission to a metallic asteroid; it launched on October 13, 2023. The contract was worth US$117 million. Europa Clipper was initially targeted to be launched on an SLS rocket. However, due to extensive delays, in 2021 NASA awarded the launch contract to SpaceX for a fully expendable Falcon Heavy. It launched on October 14, 2024. Dragonfly, a rotorcraft mission to Saturn's moon Titan, is scheduled to launch on a Falcon Heavy in July 2028. ==Gallery==

File:Falcon Heavy Demo Mission (39337245145).jpg|Falcon Heavy test flight launch File:Arabsat-6A Mission (40628442293).jpg|Arabsat-6A launch File:STP-2 Mission (48129211778).jpg|STP-2 launch File:USSF-44, Falcon Heavy, 11-01-2022 (52469536962).jpg|USSF-44 launch File:SLD 45 Supports Successful USSF 67 Mission (7600949).jpeg|USSF-67 launch File:Falcon Heavy VIASAT 3 1 Launch (7775402).jpg|ViaSat-3 F1 launch File:Psyche Launch (NHQ202310130021).jpg|Psyche launch File:X-37B mission (2003366658).jpg|OTV-7 launch File:NASA's SpaceX GOES-U Liftoff (KSC-20240625-PH-KMO02 0003).jpg|GOES-U launch File:NASA's SpaceX Europa Clipper Launch (KSC-20241014-PH-AJN01 0022) (cropped).jpg|Europa Clipper launch == See also ==