The chemical composition of syngas varies based on the raw materials and the processes. Syngas produced by
coal gasification generally is a mixture of 30 to 60% carbon monoxide, 25 to 30% hydrogen, 5 to 15% carbon dioxide, and 0 to 5% methane. It also contains lesser amount of other gases. Syngas has less than half the
energy density of
natural gas. The first reaction, between incandescent
coke and steam, is strongly endothermic, producing carbon monoxide (CO) and hydrogen (
water gas in older terminology). When the coke bed has cooled to a temperature at which the endothermic reaction can no longer proceed, the steam is then replaced by a blast of air. The second and third reactions then take place, producing an
exothermic reaction—forming initially carbon dioxide and raising the temperature of the coke bed—followed by the second endothermic reaction, in which the latter is converted to carbon monoxide. The overall reaction is exothermic, forming "producer gas" (older terminology). Steam can then be re-injected, then air etc., to give an endless series of cycles until the coke is finally consumed. Producer gas has a much lower energy value, relative to water gas, due primarily to dilution with atmospheric nitrogen. Pure oxygen can be substituted for air to avoid the dilution effect, producing gas of much higher
calorific value. In order to produce more hydrogen from this mixture, more steam is added and the
water gas shift reaction is carried out: : The hydrogen can be separated from the by
pressure swing adsorption (PSA),
amine scrubbing, and
membrane reactors. A variety of alternative technologies have been investigated, but none are of commercial value. Some variations focus on new stoichiometries such as carbon dioxide plus methane or partial
hydrogenation of carbon dioxide. Other research focuses on novel energy sources to drive the processes including electrolysis, solar energy, microwaves, and electric arcs. Electricity generated from
renewable sources is also used to process carbon dioxide and water into syngas through
high-temperature electrolysis. This is an attempt to maintain
carbon neutrality in the generation process.
Audi, in partnership with company named Sunfire, opened a pilot plant in November 2014 to generate
e-diesel using this process. Syngas that is not methanized typically has a lower heating value of 120 BTU/
scf. Untreated syngas can be run in hybrid turbines that allow for greater efficiency because of their lower operating temperatures, and extended part lifetime. ==Uses==